一、生物質氣發電技術介紹

　　1、 Introduction to Biomass Gas Power Generation Technology

　　生物質氣（biosyngas）是以農作物秸稈、林木廢棄物、食用菌渣、禽畜糞便、污水污泥等含有生物質體的物質為原料，在高溫下，生物質體熱解或者氣化分解產生的一種可燃性氣體。生物質氣中含氫15.27%、氧3.12%、氮56.22%、甲烷1.57%、一氧化碳9.76%、二氧化碳13.75%、乙烯0.10%、乙烷0.13%、丙烷0.03%、丙烯0.05%。

　　Biomass gas is a combustible gas produced by the pyrolysis or gasification of biomass at high temperatures, using materials containing biomass such as crop straw, forest waste, edible mushroom residue, livestock manure, and sewage sludge as raw materials. Biomass gas contains 15.27% hydrogen, 3.12% oxygen, 56.22% nitrogen, 1.57% methane, 9.76% carbon monoxide, 13.75% carbon dioxide, 0.10% ethylene, 0.13% ethane, 0.03% propane, and 0.05% propylene.

　　生物質氣化發電技術是指生物質在氣化爐中轉化為氣體燃料，經凈化后直接進入燃氣機中燃燒做功驅動發電機發電。生物質氣化出來的燃氣都含有一定的雜質，包括灰分、焦炭和焦油等，需經過凈化系統把雜質除去，以保證發電設備的正常運行。

　　Biomass gasification power generation technology refers to the conversion of biomass into gas fuel in a gasifier, which is purified and directly enters a gas engine for combustion and power generation to drive a generator. The gas produced by biomass gasification contains certain impurities, including ash, coke, tar, etc., which need to be removed by a purification system to ensure the normal operation of power generation equipment.

　　生物質氣發電機組融入行業內領先的燃氣燃燒控制、電控混合器等技術，可自動控制空燃比，機組具有安全、可靠、高熱效率、高性價比和全自動化運行管理等特點。該秸稈氣發電機組運行穩定、操作簡單、自動化程度高、兼顧經濟效益和環保要求，對原材料局限小，可利用稻殼、秸稈、木屑、木片、椰殼、棕櫚殼、玉米秸稈、玉米芯、亞麻桿、甘蔗渣、芒果核、花生殼等農林業廢料作原料進行發電。此系列機組可替代進口產品，整機技術處于國內領先水平。

　　The biomass gas generator unit integrates industry-leading technologies such as gas combustion control and electronic control mixer, which can automatically control the air-fuel ratio. The unit has the characteristics of safety, reliability, high thermal efficiency, high cost-effectiveness, and fully automated operation and management. The straw gas generator set operates stably, is easy to operate, has a high degree of automation, and balances economic benefits and environmental protection requirements. It has minimal limitations on raw materials and can efficiently generate electricity using agricultural and forestry waste materials such as rice husk, straw, sawdust, wood chips, coconut shells, palm shells, corn stalks, corn cobs, flax stalks, sugarcane bagasse, mango kernels, peanut shells, etc. This series of units can replace imported products, and the overall technology is at the leading level in China.

　　可根據客戶實際需要配置單套機組功率涵蓋100KW-800kw的生物質氣發電機組。對于裝機容量在1MW以上的項目，我們建議客戶使用多臺500KW的機組并機并網，綜合性價比最高。電站運行也更加穩定，維護保養方便，且維護成本低。

　　According to the actual needs of customers, a single set of biomass gas generator units with a power range of 100KW-800kw can be configured. For projects with an installed capacity of over 1MW, we recommend that customers use multiple 500KW units connected to the grid in parallel for the highest overall cost-effectiveness. The operation of the power station is also more stable, with convenient maintenance and low maintenance costs.

　　生物質氣化發電系統分成五部分：1、氣化爐；2、氣體凈化系統；3、出碳系統；4、發電系統；5、設備控制系統。原理為原料在氣化爐里高溫厭氧燃燒產生可燃氣體（氣體熱值大于1000Kcal），可燃氣經過旋風分離器，濕式凈化設備（部分地區用干式凈化系統），氣液分離設備，靜電捕焦器等將氣體凈化降溫，使氣體溫度低于40℃，然后進入氣體發電機組發電，氣化后的稻殼炭可通過碳粉收集裝置回收。整套設備無需人工手動，通過控制室操控進料，排料全過程，并且對溫度，壓力，氣體成分實時監控，定點記錄。

　　The biomass gasification power generation system is divided into five parts: 1. Gasification furnace; 2. Gas purification system; 3. Carbon removal system; 4. Power generation system; 5. Equipment control system. The principle is that raw materials are anaerobically burned at high temperatures in a gasifier to produce combustible gases (with a gas calorific value greater than 1000Kcal). The combustible gases are purified and cooled by cyclone separators, wet purification equipment (some areas use dry purification systems), gas-liquid separation equipment, electrostatic precipitators, etc., so that the gas temperature is below 40 ℃. Then they enter the gas generator set for power generation. The gasified rice husk charcoal can be recovered through a carbon powder collection device. The entire equipment does not require manual operation, and the entire process of feeding and discharging is controlled through the control room. It also monitors temperature, pressure, and gas composition in real-time and records them at designated locations.

　　二、生物質氣發電機組（部分）規格型號及技術參數：

　　2、 Specifications, models, and technical parameters of biomass gas generator units (partial):

　　機組電氣指標：額定頻率50HZ（60HZ可選），功率因數COSФ=0.8，額定電壓400/230V，相線：三相四線制;

　　Unit electrical specifications: rated frequency 50HZ (60HZ optional), power factor COS Φ=0.8, rated voltage 400/230V, phase line: three-phase four wire system;

　　若您需要了解機組其他資料、生物質氣發電機組報價或未展示的功率型號機組參數請聯系我們。

　　If you need to know other information about the unit, biomass gas generator unit quotation, or power model unit parameters not displayed, please contact us.

　　三、生物質氣發電機組技術說明

　　3、 Technical Description of Biomass Gas Generator Unit

　　1. 發電機組運行標準環境條件

　　1. Operating standard environmental conditions for generator sets

　　總大氣壓力100kPa；環境空氣溫度25℃；相對濕度30%；在上述條件下，氣源品質符合技術規定時，發電機組能達到額定負荷輸出。

　　Total atmospheric pressure 100kPa; The ambient air temperature is 25 ℃; Relative humidity of 30%; Under the above conditions, when the quality of the gas source meets the technical specifications, the generator set can achieve the rated load output.

　　2. 配套發電機可選

　　2. Optional matching generator

　　機組配套的發電機均為國內外知名品牌：利萊森瑪、西門子、斯坦福、馬拉松、英格、愛爾瑪等。

　　The generators matched with the unit are all well-known brands at home and abroad, such as Leyema, Siemens, Stanford, Marathon, Ingersoll Rand, Alma, etc.

　　四、售后服務

　　4、 After sales service

　　保修期：國內機組調試驗收合格后的12個月或累計運行1000小時；以先到期為準。由于產品質量問題實行免費維修或換件，終身有償服務！（易損件、常用件、人為損壞、疏忽保養等均不在保修范圍內）如因原廠調整則以原廠保固條例執行！

　　Warranty period: 12 months or accumulated 1000 hours of operation after domestic unit commissioning and acceptance; Whichever expires first. Due to product quality issues, we offer free repairs or replacement parts and lifetime paid services! (Vulnerable parts, commonly used parts, human damage, neglect of maintenance, etc. are not covered by the warranty) If they are adjusted by the original factory, the original factory warranty regulations shall apply!

　　保質期后，用戶享受產品終身保養，需配件更換時只收取成本費用，不加收人工費。如遇產品嚴重損耗或特殊情況，可司進行大修或對換新機。

　　After the expiration date, users enjoy lifelong maintenance of the product. If replacement parts are needed, only the cost fee will be charged, and no labor fee will be added. In case of serious product damage or special circumstances, the company can carry out major repairs or replace the machine with a new one.

　　本文由 生物質氣發電機組  友情奉獻.更多有關的知識請點擊  http://www.kmy0823.com/   真誠的態度.為您提供為的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from biomass gas generators For more related knowledge, please click http://www.kmy0823.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.